Published on 08/12/2010

Member2Member
Pin 30 to Pin 87 • Vacuum Leak • Clutch Decision • Differential Drain Plug

10 Back
Issue 29, August/September/October 2000

First Generation
Brakes on a Dana 70 with Dual Rear Wheels • Transmission Flex Plate • Fuel Shut Off Wire • Battery Charging System • Injection Pump Leak • Cold Start Engine Miss and Smoke • Cummins into 1986 Ram? • Broken Camshaft

12-Valve Engines
Fuel Heater • Fuel Lift Pump Gasket • Rebuild or Replace the Fuel Filter Canister? • Lift Pump Push Rod • Pump Timing with the Cylinder Head Removed • Front Crankshaft Seal and Service Sleeve • Installing a G56 Replacement Transmission • Replace Serpentine Belt Tensioner • Check Your Brake Lines • NV4500 Five-Speed Problems • AFC Boost Line • Best Value in Compound Turbochargers • Timing for the P7100 Pump • Are Aftermarket Intercoolers Worth the Cost? • Should I Install 60 Pound Valve Springs? • Lubricant for NV4500 Five-Speed Transmission • Holset H2E Turbo on a 12-Valve Engine? Timing for Good Fuel Mileage?

24-Valve Engines
More Intermittent Torque Converter Locking/Unlocking • Remove the Transfer Case • Transfer Case Rear Seal Leak • Crankshaft Position Sensor • NV4500 Output Shaft Leaking • Normal Injector Life • Cleaning the Intercooler • Cylinder Head Removal • Poor Turbo Spoolup • High Lube Temperature in NV5600

5.9 HP CR
Wastegate Solenoid • Remove the Oil Pan • Cooling System Maintenance • RPM is Slow to Return to Idle • Turbo V-Band Clamp • Exhaust Manifold • Fuel Leak Near Injectors • Turbo Recommendations for Towing with Modified Engine • HX40 Turbo for Towing? • Clutch for G56 Transmission

6.7 HP CR
Ramp Up Idle • Turbo Replacement • Fuel/Water Drain Seal • Engine Oil Level

Fourth Generation
Owner's Report • Transmission Temperature Gauge • Mega Cab Behind Rear Seat Storage • Disable Seat Belt Alert • U-CONNECT iPod • Factory Brake Controller • Week Long Recap of the 2010 HD Truck • Fuel Filter Change • No Remote Start

Technical Topics
Bringing It Together (Emissions Controls) • Sidebar: Your Cummins Engine the Catalytic Trap • The Auto Cat Versus the Diesel Cat

Cummins' Column
California Emissions Recall K01 / Reprogram ECU - OBD Readiness • Emissions Recall J35 / Reprogram ECU - Regeneration Strategy

Four Whaling
It's All Hype and BS (Pickup Hype and Comparison Test) • Another Kind of Hype and BS - Event Data Recorders

Have Ram, Will Travel
Intercoolers, A Few Afterthoughts • First Generation Adventures: Power Steering Hoses and Differential Covers • NV4500 Tail Housing • Third Generation Injectors, Again • Installing the 98-Gallon Cross-Bed Transfer Flow Auxiliary Fuel Tank

TDRV
Batteries • Industry Status • Trailer Axle Spacing • Fifth-Wheel Trailer Tow Wire Harness

From the Shop Floor
KDP-Killer Dowel Pin • 12-Valve Fuel Heater Saga ('89-'99 Model Years) • U-Joint Replacement • Transmission Noise Filter ('94-'02) • 2003 Turbo Diesel - Low Power, Could it be Asthma? • Missing High Idle Control for 2005/2006/2007 Turbo Diesels (Manual Transmissions)