Published on 11/17/2011

Tailgating
Issue 34 Review

10 Back
Issue 34, November/December/January 2001 (Industry News • Feature Article - EGT Gauge Evaluation • Baja Trip • The TDR Buyer's Guide • Chapter News, Events and Travel

Member2Member
Steering Woes • Steering Woes on Second Generation 4X4

First Generation
Fan Clutch Removal • Power Steering Hoses • Water Pump O-Ring Leaking • Replacing a Pinion Seal • Accelerator Pedal Vibration • Fuel Sending Unit • Oil in Coolant Reservoir • Buyer's Information • How to Remove the Rotor From the Hub? • Auxiliary Transmission Cooler • Best Coolant for My First Generation

12-Valve Engines
Fuel Gauge • Erratic Speedometer • An Easy Method to Remove a Rotor • Drain the Radiator • Radiator Fan • Headlight Gremlin • Torque Plate Contour • How to Set P7100 Pump Timing • Transmission Cooler Lines • Repairing Battery Cable Terminals • Upgrades and EGT Issues • Solvent for Adjusting Timing • Engine Popping at High RPM

24-Valve Engines
Engine Surging/Bucking • Replace the Axle? • Largest Injectors for Stock Turbo? • Engine Control Module/Wait To Start Light • Thermostat Housing Bolts • More Torque Convertor Intermittent Lock/Unlock

5.9 HP CR
Engine Won't Run • Water Pump • 48RE "Hunting" • Coolant/Transmission Fluid Heat Exchanges • No Reverse on NV5600 • Power Steering Cap Blowing Off • Knocking in Injector Line • Choosing a Bigger Intercooler • Backlash in G56 Transmission

6.7 HP CR
Insight From the Insight of the Cost of Regeneration • Codes PO137/P2A01, What To Do? • Exhaust Brake Whistle • Transmission Leak • Check Gauges and Electronic Throttle Control Light On • Noise in the Turbo Area • Engine Dying at Idle

Fourth Generation
Fresh Cabin Air and a Hot Butter Knife • Integrated Brake Controller • Fuel in the Engine Oil • Lube the Cardan Joint? • Speedometer Recalibration • Website For Tracking a Truck on Order • Loose Lug Nuts and an Oil Seep • Harsh Shifting From Forward to Reverse • Factory Spray-in Bedliner Versus LineX • 4500/5500 With Urea

TDResource
2011 Technical Service Bulletins

TDReview
TDR is in the (Open) House

Your Story
The Continuing Story of Mr. Schwarz

Four Whaling
Eye on the Ball for Thumbs on the Wheel • Eyes on Reality • Eye on the Bouncing Fuel Standards Ball • The Bigger Ball (Fuel Consumption Standards)

Motor Minded
To Assume

Idle Clatter
Black Oil • Fuel Dilution • Rear Axle Lube Change • The Number One Question! • Exhaust Brake, On or Off? • Check Engine Light • I Smell Fuel! • Unintended Consequences • 12-Valve Throttle Linkage

Ranch Dressing
Codes, Causes and Concerns - Continued

Have Ram, Will Travel
Vacuum Pump Seal Kit • The Cargo or Car-Hauler Trailer • Bosch CP3 High Pressure Fuel Injection Pump • Power Steering Pump

Back In The Saddle
Fuelin' Around • Bitchin' Hitchin' and Gauges • New Wheels and Tires - Turnin' and Burnin' • 47RH Transmission Modifications